Badger Meter (BMI) 10-Q 2008 Q2 Quarterly report

UNITED STATES
SECURITIES AND EXCHANGE COMMISSION

Washington, D.C. 20549

FORM 10-Q

Quarterly Report Pursuant to Section 13 or 15(d) of the Securities Exchange Act of 1934
for the quarterly period ended June 30, 2008

BADGER METER, INC.

4545 W. Brown Deer Road
Milwaukee, Wisconsin 53223
(414) 355-0400
A Wisconsin Corporation
IRS Employer Identification No. 39-0143280
Commission File No. 1-6706

     Indicate by check mark whether the registrant (1) has filed all reports required to be filed by Section 13 or 15(d) of the Securities Exchange Act of 1934 during the preceding 12 months (or for such shorter period that the registrant was required to file such reports), and (2) has been subject to such filing requirements for the past 90 days.

Yesþ  Noo

      Indicate by check mark whether the registrant is a large accelerated filer, an accelerated filer, a non-accelerated filer or a smaller reporting company. See definitions of “large accelerated filer,” “accelerated filer” and “smaller reporting company” in Rule 12b-2 of the Exchange Act. (Check one):

Large accelerated filero  Accelerated filerþ  Non-accelerated filero
(Do not check if a smaller reporting company) Smaller reporting companyo 

     Indicate by check mark whether the registrant is a shell company (as defined in Rule 12b-2 of the Exchange Act).

Yeso  Noþ

     As of July 15, 2008, there were 14,655,385 shares of Common Stock outstanding with a par value of $1 per share.

BADGER METER, INC.

Quarterly Report on Form 10-Q for Period Ended June 30, 2008

Index

	Page No.
Part I. Financial Information:		4
Item 1 Financial Statements:		4
Consolidated Condensed Balance Sheets — June 30, 2008 and December 31, 2007		4
Consolidated Condensed Statements of Operations — Three and Six Months Ended June 30, 2008 and 2007		5
Consolidated Condensed Statements of Cash Flows — Six Months Ended June 30, 2008 and 2007		6
Notes to Unaudited Consolidated Condensed Financial Statements		7
Item 2 Management’s Discussion and Analysis of Financial Condition and Results of Operations		10
Item 3 Quantitative and Qualitative Disclosures about Market Risk		14
Item 4 Controls and Procedures		15
Part II. Other Information:		15
Item 4 Submission of Matters to a Vote of Security Holders		15
Item 6 Exhibits		16
Signatures		17
Exhibit Index		18
Exhibit 4.1
Exhibit 31.1
Exhibit 31.2
Exhibit 32

2

Special Note Regarding Forward Looking Statements

          Certain statements contained in this Form 10-Q, as well as other information provided from time to time by Badger Meter, Inc. (the “Company”) or its employees, may contain forward looking statements that involve risks and uncertainties that could cause actual results to differ materially from those in the forward looking statements. The words “anticipate,” “believe,” “estimate,” “expect,” “think,” “should” and “objective” or similar expressions are intended to identify forward looking statements. All such forward looking statements are based on the Company’s then current views and assumptions and involve risks and uncertainties that include, among other things:

• the continued shift in the Company’s business from lower cost, manual read meters toward more expensive, value-added automatic meter reading (AMR) systems and advanced metering infrastructure (AMI) systems;

• the success or failure of newer Company products, including the Orion® radio frequency AMR system, the Galaxy® fixed network AMI system and the low profile Recordall® Model LP disc series meter;

• changes in competitive pricing and bids in both the domestic and foreign marketplaces, and particularly in continued intense price competition on government bid contracts for lower cost, manual read meters;

• the actions (or lack thereof) of the Company’s competitors;

• changes in the Company’s relationships with its alliance partners, primarily its alliance partners that provide AMR/AMI connectivity solutions, and particularly those that sell products that do or may compete with the Company’s products;

• changes in the general health of the United States and foreign economies, including, to some extent, housing starts in the United States and overall industrial activity;

• increases in the cost and/or availability of needed raw materials and parts, including recent increases in the cost of brass castings as a result of increases in commodity prices, particularly for copper and scrap metal, at the supplier level and plastic resin as a result of increases in petroleum and natural gas prices;

• the Company’s expanded role as a prime contractor for providing complete AMR/AMI systems to governmental entities, which brings with it added risks, including but not limited to, Company responsibility for subcontractor performance; additional costs and expenses if the Company and its subcontractors fail to meet the agreed-upon timetable with the governmental entity; and the Company’s expanded warranty and performance obligations;

• changes in foreign economic conditions, particularly currency fluctuations between the United States dollar and the euro;

• the loss of certain single-source suppliers; and

• changes in laws and regulations, particularly laws dealing with the use of lead (which can be used in the manufacture of certain meters incorporating brass housings) and the U.S. Federal Communications Commission rules affecting the use and/or licensing of radio frequencies necessary for AMR/AMI products.

          All of these factors are beyond the Company’s control to varying degrees. Shareholders, potential investors and other readers are urged to consider these factors carefully in evaluating the forward looking statements and are cautioned not to place undue reliance on such forward looking statements. The forward looking statements made in this document are made only as of the date of this document and the Company assumes no obligation, and disclaims any obligation, to update any such forward looking statements to reflect subsequent events or circumstances.

3

Part I — Financial Information

Item 1 Financial Statements

BADGER METER, INC.

Consolidated Condensed Balance Sheets

	June 30,			December 31,
	2008			2007
	(Unaudited)
	(In thousands)
Assets
Current assets:
Cash and cash equivalents	$	5,401		$	8,670
Receivables		38,043			30,638
Inventories:
Finished goods		8,758			8,225
Work in process		15,150			10,660
Raw materials		15,621			15,209
Total inventories		39,529			34,094
Prepaid expenses and other current assets		4,485			3,450
Deferred income taxes		3,101			3,082
Total current assets		90,559			79,934
Property, plant and equipment, at cost		132,727			125,678
Less accumulated depreciation		(73,549	)		(71,100	)
Net property, plant and equipment		59,178			54,578
Intangible assets, at cost less accumulated amortization		25,742			477
Other assets		5,535			4,919
Deferred income taxes		3,435			3,435
Goodwill		6,958			6,958
Total assets	$	191,407		$	150,301
Liabilities and shareholders’ equity
Current liabilities:
Short-term debt	$	32,688		$	10,844
Current portion of long-term debt		2,116			2,738
Payables		14,798			11,363
Accrued compensation and employee benefits		7,017			5,988
Warranty and after-sale costs		2,008			1,917
Income and other taxes		10,907			8,359
Total current liabilities		69,534			41,209
Other long-term liabilities		580			627
Deferred income taxes		251			244
Accrued non-pension postretirement benefits		6,252			6,083
Other accrued employee benefits		7,094			7,040
Long-term debt		2,714			3,129
Commitments and contingencies
Shareholders’ equity:
Common stock		20,929			20,902
Capital in excess of par value		25,817			24,655
Reinvested earnings		99,505			89,061
Accumulated other comprehensive loss		(8,427	)		(9,191	)
Less:Employee benefit stock		(658	)		(682	)
Treasury stock, at cost		(32,184	)		(32,776	)
Total shareholders’ equity		104,982			91,969
Total liabilities and shareholders’ equity	$	191,407		$	150,301

See accompanying notes to consolidated condensed financial statements.

4

BADGER METER, INC.

Consolidated Condensed Statements of Operations

	Three Months Ended					Six Months Ended
	June 30,					June 30,
	(Unaudited)					(Unaudited)
	(In thousands except share and per share amounts)
	2008		2007			2008			2007
Net sales	$	74,660	$	62,173		$	143,080		$	114,836
Cost of sales		48,286		39,639			92,182			76,047
Gross margin		26,374		22,534			50,898			38,789
Selling, engineering and administration		14,624		13,118			29,279			25,103
Operating earnings		11,750		9,416			21,619	��		13,686
Interest expense		335		315			587			667
Earnings from continuing operations before income taxes		11,415		9,101			21,032			13,019
Provision for income taxes		4,374		3,381			7,971			4,830
Earnings from continuing operations		7,041		5,720			13,061			8,189
Loss from discontinued operations net of income taxes		—		(252	)		—			(149	)
Net earnings	$	7,041	$	5,468		$	13,061		$	8,040
Earnings (loss) per share amounts:
Basic:
from continuing operations	$	0.49	$	0.40		$	0.90		$	0.58
from discontinued operations	$	—	$	(0.01	)	$	—		$	(0.01	)
Total basic	$	0.49	$	0.39		$	0.90		$	0.57
Diluted:
from continuing operations	$	0.48	$	0.39		$	0.88		$	0.56
from discontinued operations	$	—	$	(0.01	)	$	—		$	(0.01	)
Total diluted	$	0.48	$	0.38		$	0.88		$	0.55
Dividends declared	$	0.09	$	0.08		$	0.18		$	0.16
Shares used in computation of earnings per share:
Basic		14,509,709		14,167,554			14,466,785			14,102,764
Impact of dilutive securities		314,127		399,466			334,751			440,340
Diluted		14,823,836		14,567,020			14,801,536			14,543,104

See accompanying notes to consolidated condensed financial statements.

5

BADGER METER, INC.

Consolidated Condensed Statements of Cash Flows

	Six Months Ended
	June 30,
	(Unaudited)
	(In thousands)
	2008			2007
Operating activities:
Net earnings	$	13,061		$	8,040
Adjustments to reconcile net earnings to net cash provided by (used for) operations:
Depreciation		3,336			3,372
Amortization		385			82
Deferred income taxes		(19	)		(11	)
Noncurrent employee benefits		1,721			1,315
Stock-based compensation expense		573			445
Gain on disposal of long-lived assets		—			(495	)
Changes in:
Receivables		(7,083	)		(7,397	)
Inventories		(5,223	)		(516	)
Prepaid expenses and other current assets		(990	)		(685	)
Current liabilities other than debt		4,572			6,440
Total adjustments		(2,728	)		2,550
Net cash provided by operations		10,333			10,590
Investing activities:
Property, plant and equipment additions		(7,490	)		(9,904	)
Proceeds on disposal of long-lived assets		—			3,194
Acquisition of intangible assets		(25,650	)		—
Other — net		(621	)		(10	)
Net cash provided by (used for) investing activities		(33,761	)		(6,720	)
Financing activities:
Net increase (decrease) in short-term debt		21,649			(64	)
Repayments of long-term debt		(1,037	)		(956	)
Dividends paid		(2,612	)		(2,275	)
Proceeds from exercise of stock options		968			719
Tax benefit on stock options		1,673			910
Issuance of treasury stock		74			95
Net cash provided by (used for) financing activities		20,715			(1,571	)
Effect of foreign exchange rates on cash		(556	)		(54	)
Increase (decrease) in cash		(3,269	)		2,245
Cash — beginning of period from continuing operations		8,670			3,002
Cash — beginning of period from discontinued operations		—			2,046
Cash — beginning of period		8,670			5,048
Cash — end of period from continuing operations		5,401			5,991
Cash — end of period from discontinued operations		—			1,302
Cash — end of period	$	5,401		$	7,293

See accompanying notes to consolidated condensed financial statements.

6

BADGER METER, INC.

Notes to Unaudited Consolidated Condensed Financial Statements

Note 1 Basis of Presentation

          In the opinion of management, the accompanying unaudited consolidated condensed financial statements of Badger Meter, Inc. (the “Company”) contain all adjustments (consisting only of normal recurring accruals except as otherwise discussed) necessary to present fairly the Company’s consolidated condensed financial position at June 30, 2008, results of operations for the three- and six-month periods ended June 30, 2008 and 2007, and cash flows for the six-month periods ended June 30, 2008 and 2007. The results of operations for any interim period are not necessarily indicative of the results to be expected for the full year.

          The preparation of financial statements in conformity with U.S. generally accepted accounting principles requires management to make estimates and assumptions that affect the amounts reported in the financial statements and accompanying notes. Actual results could differ from those estimates.

Note 2 Additional Balance Sheet Information

          The consolidated condensed balance sheet at December 31, 2007 was derived from amounts included in the Company’s Annual Report on Form 10-K for the year ended December 31, 2007. Refer to the footnotes to the financial statements included in that report for a description of the Company’s accounting policies and for additional details of the Company’s financial condition. The details in those notes have not changed except as discussed below and as a result of normal adjustments in the interim.

          Warranty and After-Sale Costs

          The Company estimates and records provisions for warranties and other after-sale costs in the period in which the sale is recorded, based on a lag factor and historical warranty claim experience. After-sale costs represent a variety of activities outside of the written warranty policy, such as investigation of unanticipated problems after the customer has installed the product, or analysis of water quality issues. Changes in the Company’s warranty and after-sale costs reserve for the six-month periods ended June 30, 2008 and 2007 are as follows:

	Balance at		Net additions					Balance
	beginning		charged to		Costs			at
(In thousands)	of year		earnings		incurred			June 30
2008	$	1,917	$	577	$	(486	)	$	2,008
2007	$	2,954	$	173	$	(492	)	$	2,635

Note 3 Employee Benefit Plans

          The Company maintains a non-contributory defined benefit pension plan for its domestic employees and a non-contributory postretirement plan that provides medical benefits for certain domestic retirees and eligible dependents. The following table sets forth the components of net periodic benefit cost for the three months ended June 30, 2008 and 2007 based on a September 30 measurement date:

							Other
							postretirement
	Pension benefits						benefits
(In thousands)	2008			2007			2008		2007
Service cost	$	493		$	496		$	37	$	49
Interest cost		686			629			101		105
Expected return on plan assets		(864	)		(883	)		—		—
Amortization of prior service cost (credit)		(36	)		(37	)		45		—
Amortization of net loss		290			282			8		28
Net periodic benefit cost	$	569		$	487		$	191	$	182

7

          The following table sets forth the components of net periodic benefit cost for the six months ended June 30, 2008 and 2007 based on a September 30 measurement date:

							Other
							postretirement
	Pension benefits						benefits
(In thousands)	2008			2007			2008		2007
Service cost	$	986		$	992		$	74	$	98
Interest cost		1,372			1,258			202		210
Expected return on plan assets		(1,728	)		(1,766	)		—		—
Amortization of prior service cost (credit)		(72	)		(74	)		90		—
Amortization of net loss		580			564			16		55
Net periodic benefit cost	$	1,138		$	974		$	382	$	363

          The Company previously disclosed in its financial statements for the year ended December 31, 2007 that it did not expect to contribute funds to its pension plan in 2008. While the Company believes that it will not be required to make any such contributions in 2008, such belief is based upon the estimated return on plan assets as of the annual measurement date.

          The Company disclosed in its financial statements for the year ended December 31, 2007 that it estimated it would pay $0.6 million in other postretirement benefits in 2008 based on actuarial estimates. As of June 30, 2008, $106,000 of such benefits were paid. The Company now believes that its estimated payments for the full year may be somewhat less than the full-year estimate. However, such estimates contain inherent uncertainties because cash payments can vary significantly depending on the timing of postretirement medical claims and the collection of the retiree’s portion of certain costs. Note that the amount of benefits paid in calendar year 2008 will not impact the expense for postretirement benefits for the current year.

          In September 2006, the Financial Accounting Standards Board (FASB) issued Statement No. 158, “Employers’ Accounting for Defined Benefit Pension and Other Postretirement Plans, an amendment of FASB Statements No. 87, 88, 106 and 132(R)” (SFAS 158). On December 31, 2006, the Company adopted the required provisions of SFAS 158 by recognizing the funded status of its defined benefit pension and postretirement benefit plans in the statement of financial position. Additionally, employers are required to measure the funded status of a plan as of the date of its year-end statement of financial position and provide additional disclosures. Prior to the adoption of the measurement date provisions of SFAS 158, the Company’s pension plans previously used a September 30 measurement date. As permitted by the statement, the Company will adopt the measurement provisions of SFAS 158 during the fourth quarter for the 2008 full-year statements, at which time the Company expects to recognize a reduction of $0.4 million, net of tax, to the 2008 beginning of the year reinvested earnings. There will be no effect on the Company’s results of operations or cash flows.

Note 4 Guarantees

          The Company guarantees the outstanding debt of the Badger Meter Employee Savings and Stock Ownership Plan (“ESSOP”) that is recorded in long-term debt, offset by a similar amount of unearned compensation that has been recorded as a reduction of shareholders’ equity. The loan amount is collateralized by shares of the Company’s Common Stock. A payment of $23,000 was made in the first quarter of 2008 that reduced the debt and the corresponding employee benefit stock balance included in shareholders’ equity.

Note 5 Comprehensive Income (Loss)

          Comprehensive income for the three-month periods ended June 30, 2008 and 2007 was $7.2 million and $5.7 million, respectively. Comprehensive income for the six-month periods ended June 30, 2008 and 2007 was $13.8 million and $8.4 million, respectively.

          Components of accumulated other comprehensive loss are as follows:

	June 30,			December 31,
(In thousands)	2008			2007
Cumulative foreign currency translation adjustment	$	2,063		$	1,713
Unrecognized pension and postretirement benefit plan liabilities		(10,490	)		(10,904	)
Accumulated other comprehensive loss	$	(8,427	)	$	(9,191	)

8

Note 6 Discontinued French Operations

          During 2006, the Company carefully evaluated strategic alternatives for its subsidiaries in Nancy, France, including restructuring, sale or shutdown. In the third quarter of 2006, the Company began the process under French law to obtain the approvals to close the operations. On October 16, 2006, the decision to discontinue the Company’s French operations was finalized, and all disposal transactions were completed by December 31, 2007. Information about the Company’s discontinued French operations is included in the Notes to Consolidated Financial Statements in the Company’s 2007 Annual Report on Form 10-K under the heading “Note 3 Discontinued Operations.”

          For the three-month period ended June 30, 2007, net sales from the French operations were $58,000 and net losses were $0.3 million. For the six-month period ended June 30, 2007, net sales from the French operations were $1.9 million and net losses were $0.1 million.

Note 7 Acquisition of Intangible Assets

          In April 2008, the Company acquired the advanced metering infrastructure (AMI) technology used in its Galaxy® fixed network system from Miltel Communications Ltd. for a purchase price of approximately $25.7 million. The technology agreement included the acquisition of the core technology, the exclusive right to manufacture the Galaxy® system and distribute it in certain water and gas utility markets, and a non-compete clause. The purchase price was recorded in the second quarter of 2008 as intangible assets that will be amortized over estimated lives of 20 and 10 years for the core technology and non-compete arrangement, respectively. This acquisition was initially funded from commercial paper drawn on the Company’s short-term line of credit, which was amended in April 2008 to increase availability to accommodate this purchase.

          In July 2008, the Company obtained a $15.0 million unsecured two-year loan that bears interest at 5.04% annually to refinance a portion of the existing short-term debt that funded this acquisition.

Note 8 Restricted Stock

          On April 25, 2008, a restricted stock plan was approved which provides for the issuance of non-vested Common Stock to certain eligible employees. The plan authorizes the issuance of shares up to an aggregate of 100,000 shares of Common Stock (no individual participant may be granted more than 20,000 shares in the aggregate), of which 5,100 were issued in May 2008. The restricted stock issued in May is generally subject to a three-year cliff vesting period contingent on employment. Compensation expense related to the issuance of restricted stock was $37,881 for the quarter ended June 30, 2008.

Note 9 Contingencies, Litigation and Commitments

          In the normal course of business, the Company is named in legal proceedings from time to time. There are currently no material legal proceedings pending with respect to the Company. The more significant legal proceedings are as discussed below.

          The Company is subject to contingencies related to environmental laws and regulations. Currently, the Company is in the process of resolving matters relating to two landfill sites where it has been named as one of many potentially responsible parties. These sites are impacted by the Federal Comprehensive Environmental Response, Compensation and Liability Act and other environmental laws and regulations. At this time, the Company does not believe the ultimate resolution of these issues will have a material adverse effect on the Company’s financial position or results of operations, either from a cash flow perspective or on the financial statements as a whole. This belief is based on the Company’s assessment of its limited past involvement with these sites as well as the substantial involvement of other named third parties in these matters. However, due to the inherent uncertainties of such proceedings, the Company cannot predict the ultimate outcome of these matters. A future change in circumstances with respect to these specific matters or with respect to sites formerly or currently owned or operated by the Company, or with respect to off-site disposal locations used by the Company, could result in future costs to the Company and such amounts could be material.

          Like other companies in recent years, the Company has been named as a defendant in numerous multi-claimant/multi-defendant lawsuits alleging personal injury as a result of exposure to asbestos, manufactured by third parties, and integrated into or sold with a very limited number of the Company’s products. The Company is

9

vigorously defending itself against these claims. Although it is not possible to predict the ultimate outcome of these matters, the Company does not believe the ultimate resolution of these issues will have a material adverse effect on the Company’s financial position or results of operations, either from a cash flow perspective or on the financial statements as a whole. This belief is based in part on the fact that no claimant has demonstrated exposure to products manufactured or sold by the Company and that a number of cases have been voluntarily dismissed.

          The Company has evaluated its worldwide operations to determine whether any risks and uncertainties exist that could severely impact its operations in the near term. Although the Company relies on single suppliers for certain castings and components in several of its product lines, alternate sources of supply exist for these items. Loss of certain suppliers could temporarily disrupt operations in the short term. The Company attempts to mitigate these risks by working closely with key suppliers, purchasing minimal amounts from alternative suppliers and by purchasing business interruption insurance where appropriate.

          The Company reevaluates its risks on a periodic basis and makes adjustments to reserves as appropriate.

Item 2 Management’s Discussion and Analysis of Financial Condition and Results of Operations

Business Description and Overview

          The Company is a leading manufacturer and marketer of products incorporating liquid flow measurement and control technologies, which are developed both internally and in conjunction with other technology companies. Its products are used to measure and control the flow of liquids in a wide variety of applications. The Company’s product lines fall into two general categories, utility and industrial flow measurement. The utility category is comprised of two primary product lines — residential and commercial water meters that are used by water utilities as the basis for generating water and wastewater revenues. The market for these product lines is North America, primarily the United States, because these meters are designed and manufactured to conform to standards promulgated by the American Water Works Association. The utility flow measurement products constitute a majority of the Company’s sales.

          Industrial product line sales comprise the remainder of the Company’s sales and include precision valves, electromagnetic inductive flow meters, impeller flow meters, and turbine and positive displacement industrial flow meters. Rounding out the industrial product line are automotive fluid meters for the measurement of various types of automotive fluids.

          Residential and commercial water meters generally have been classified as either manual read meters or remote read meters via radio technology. A meter that is manually read consists of the water meter and a register displaying the meter reading. Remotely read meters are equipped with radio technology and convert the mechanical measurement to a digital format which is then transmitted via radio frequency to a receiver that collects and formats the data appropriately for the utility’s billing computer. Drive-by systems are referred to as automatic meter reading (AMR) systems and have been the primary technology deployed by water utilities over the past decade, providing cost effective and accurate billing data. In a drive-by AMR system, a vehicle equipped for meter reading purposes collects meter reading data.

          Fixed network advanced metering infrastructure (AMI) systems are of growing interest to water utilities. These systems do not rely on a drive-by data collector, but rather incorporate a network of data collectors that are always active or listening to the radio transmission from the utility’s meters. Not only do fixed network systems eliminate the need for meter readers, but they have the ability to provide the utility with more frequent and diverse data at specified intervals. The Company’s response to the increased interest in AMI systems is further detailed in the Business Trends section below.

          The Company’s net sales and corresponding net earnings depend on unit volume and mix of products, with the Company generally earning higher margins on meters equipped with AMR or AMI technology. In addition to selling its proprietary AMR/AMI products including the Orion® drive-by AMR technology and the Galaxy® fixed network AMI system, the Company also remarkets the Itron® drive-by AMR product under a license and distribution agreement. The Company’s proprietary AMR/AMI products generally result in higher margins than the non-proprietary AMR/AMI products that the Company remarkets.

          One distinctive advantage of the Orion® AMR technology over other AMR products is that while it is fundamentally a drive-by AMR system, the proprietary receiver technology of Orion® has been licensed to other

10

technology providers, including those providing AMR/AMI products that communicate over power lines, broadband networks, municipal WiFi and proprietary radio frequency networks.

          Utility meter sales, including sales of AMR and AMI products within this category, are generally derived from the water meter replacement requirements of customers, along with their plans for adoption and deployment of new technology. To a much lesser extent, housing starts also contribute to the base of new product sales. Over the last decade there has been a growing trend in the conversion to AMR/AMI from manually read water meters. This conversion rate is accelerating and contributing to an increased base of business available to meter and AMR/AMI producers. It is currently estimated that approximately 25-30% of water meters installed in the United States have been converted to AMR/AMI systems. Badger Meter’s strategy is to solve customers’ metering needs with its proprietary meter reading systems or other systems available through its alliance partners in the marketplace.

          The industrial products generally serve a variety of niche flow measurement applications across a broad range of industries. Some of the flow measurement technologies now used industrially, such as positive displacement and turbine flow measurement, were derived from utility meter technologies. Other technologies are very specific to industrial applications. In addition, a growing requirement is for industrial meters to be equipped with specialized communication protocols that control the entire flow measurement process. Serving both the utility and industrial flow measurement market enables the Company to use its wide variety of technology for specific flow measurement and control applications, as well as to utilize existing capacity and spread fixed costs over a larger sales base.

Business Trends

          AMI is the growing standard of technology deployment in the electric utility industry. AMI provides an electric utility with two-way communication to monitor and control electrical devices at the customer’s site. AMI deployments are always fixed network technologies. Although the Company does not participate in the electric utility market, the trend toward AMI is now affecting the water and gas utility AMR market as well. Specifically, in the water industry, fixed network AMI enables the water utility to capture interval readings from each meter on a daily basis. While two-way communication is extremely limited in water fixed network AMI, utilities are contemplating how two-way networks could benefit them. As noted above, the Company markets the Orion® drive-by AMR product line as well as the Galaxy® fixed network AMI product line. The Company is positioned to sell either product as this trend continues. Since both products have comparable margins, any acceleration or slowdown in this trend is not expected to have a significant impact on the Company.

          Although there is growing interest in fixed network communication by water utilities, the vast majority of utilities currently installing AMR/AMI are selecting drive-by AMR technologies for their applications. The Company’s Orion® technology has experienced rapid acceptance in the United States. By the end of 2007, more than 1,000 water utilities had selected Orion® as their AMR solution of choice. There are approximately 53,000 water utilities in the United States and the Company estimates that less than 30% of their services have been converted to an AMR technology. It is anticipated that even with growing interest in fixed network AMI, drive-by AMR will continue to be the primary product of choice by water utilities for a number of years. Drive-by AMR technology is simply the lowest cost form of AMR currently available to water utilities.

          Prior to the Company’s introduction of its own proprietary Orion® products, Itron® water utility-related products were a significant contributor to the Company’s results. Itron® products are sold under an agreement between the Company and Itron, Inc. that expires in early 2009 and the Company is currently discussing with Itron an extension of the agreement. The Company’s Orion® products directly compete with Itron® water AMR products and, in recent years, many of the Company’s customers have selected Orion® products. In 2007, Orion® sales increased 24.8% compared to 2006 while Itron® licensed product sales decreased 21.7% compared to 2006. For the first six months of 2008, Orion® sales were 2.5 times greater than those of the remarketed Itron® sales. The Company expects this trend to continue, although the Company also believes that Itron® licensed products will remain a significant component of utility sales. To date, decreases in sales of the remarketed Itron® licensed products have been offset by increases in sales of Orion® products, which produce a higher gross margin than the remarketed Itron® licensed products. As a result, the Company does not expect this trend to have a material negative impact on the Company’s financial position or results of operations.

Results of Operations — Three Months Ended June 30, 2008

          Net sales for the three months ended June 30, 2008 increased $12.5 million, or 20.1%, to $74.7 million from $62.2 million in the same period in 2007. The increase was driven by higher sales of the Company’s products, especially AMR products, due to higher volumes and increased prices.

11

          Residential and commercial water meter and related automation sales represented 83.3% of total net sales for the quarter compared with 80.6% in the second quarter of 2007. These sales were $62.2 million, an increase of $12.1 million, or 24.2%, from $50.1 million in the same period in 2007. This increase was due to increased volumes in units utilizing AMR/AMI technology as well as increased sales of commercial meters. Price increases also contributed to the higher sales amount. Sales of the Company’s proprietary AMR product, Orion®, and the remarketed Itron® product increased 9.1% and 39.0%, respectively, over the sales amounts for the second quarter of 2007. While the Itron® related sales show a larger percentage increase than Orion®, the Orion® products outsold the Itron® by a ratio of more than 2.2 to 1 in the three-month period ended June 30, 2008. Commercial meter revenues increased by more than 35% due to both volume and price increases.

          Industrial sales represented 16.7% of the total net sales for the quarter ended June 30, 2008 compared with 19.4% for the same period in 2007. The decline in the percentage occurred despite a modest increase in industrial sales revenues. Industrial sales were $12.5 million in the second quarter of 2008, an increase of 3.3% over sales of $12.1 million in the same period in 2007. This increase was the net effect of substantially higher sales of valves, a modest increase in impeller sales, and decreases in the other industrial product lines caused primarily by volume declines related to the weaker economy.

          The total gross margin percentage declined in the second quarter of 2008 to 35.3% from 36.2% for the same period in 2007. The decline was primarily due to product mix in the quarter, offset in part by price increases. The Company generally makes a higher margin on its proprietary products than on remarketed products. The second quarter of 2008 had a higher proportion of remarketed products than the same period in 2007. In addition, the Company experienced increased costs of materials and freight-related charges that were largely offset by price increases.

          Selling, engineering and administration costs increased $1.5 million, or 11.5%, for the three months ended June 30, 2008 compared to the same period in 2007. This was primarily the result of increased costs associated with higher sales volumes, consulting costs associated with sales process enhancements, increased research and development costs, the effects of foreign exchange and increased intangible amortization due to the acquisition of the Galaxy® technology early in the second quarter of 2008. In addition, the Company experienced normal inflationary increases, which were somewhat offset by continuing cost containment efforts.

          The provision for income taxes as a percentage of earnings from continuing operations for the second quarter of 2008 was 38.3% compared to 37.1% for the same period in 2007 and was slightly higher mainly due to certain foreign exchanges tax effects.

          As a result of the above mentioned items, earnings from continuing operations were $7.0 million for the three months ended June 30, 2008 compared to $5.7 million for the three months ended June 30, 2007. On a diluted basis, earnings per share from continuing operations were $0.48 and $0.39 for the same periods, respectively.

Results of Operations — Six Months Ended June 30, 2008

          Net sales for the six months ended June 30, 2008 increased nearly $28.2 million, or 24.6%, to $143.1 million from $114.8 million in the same period in 2007. The increase was driven by higher sales of the Company’s products, especially AMR products, due to higher volumes and increased prices.

          Residential and commercial water meter and related automation net sales represented 82.3% of total sales for the first six months of 2008 compared with 78.8% in the same period in 2007. These sales were $117.7 million, an increase of $27.3 million, or 30.2%, from $90.4 million in the same period in 2007. This increase was due to increased volumes in units utilizing AMR/AMI technology as well as increased sales of commercial meters. Price increases also contributed to the higher sales amount. Sales of the Company’s proprietary AMR product, Orion®, and the remarketed Itron® product increased 25.8% and 24.5%, respectively, over the sales amounts for the first six months of 2007. The ratio of Orion® to Itron® sales was 2.5 to 1 for the six months ended June 30, 2008. Commercial meter revenues increased 40% due to both volume and price increases. The increases were also due in part to the fact that sales in the first quarter of 2007 were negatively impacted by the timing of orders.

          Industrial sales represented 17.7% of the total net sales for the six months ended June 30, 2008 compared with 21.2% for the same period in 2007. The decline in percentage occurred despite a modest increase in industrial sales revenues. Industrial sales were $25.4 million for the first six months of 2008, an increase of 4.1% over sales of $24.4 million in the same period in 2007. This increase was the net effect of

12

substantially higher sales of valves, flat to modest increases in automotive and electromagnetic meter sales, and decreases in the other industrial product lines caused primarily by volume declines related to the weaker economy.

          The total gross margin percentage for the first six months of 2008 was 35.6% compared to 33.8% for the same period in 2007. The increase was the net effect of higher sales volumes that absorbed fixed manufacturing costs and increased prices, offset by higher costs of raw materials.

          Selling, engineering and administration costs increased $4.2 million or 16.6% for the six months ended June 30, 2008 compared to the same period in 2007. This was primarily the result of increased sales costs related to efforts to establish a presence for Orion® in the natural gas industry, increased costs associated with higher sales volumes, consulting costs associated with sales process enhancements, increased research and development costs, the effects of foreign exchange, and increased intangible amortization related to the acquisition of the Galaxy® technology early in the second quarter of 2008. In addition, the Company experienced normal inflationary increases, which were somewhat offset by continuing cost containment efforts.

          The provision for income taxes as a percentage of earnings from continuing operations for the second quarter of 2008 was 37.9% compared to 37.1% for the same period in 2007 and was slightly higher mainly due to certain foreign exchanges tax effects.

          As a result of the above mentioned items, earnings from continuing operations were $13.1 million for the six months ended June 30, 2008 compared to $8.2 million for the six months ended June 30, 2007. On a diluted basis, earnings per share from continuing operations were $0.88 and $0.56 for the same periods, respectively.

Liquidity and Capital Resources

          The main sources of liquidity for the Company are cash from operations and borrowing capacity. Cash provided by operations for the first six months of 2008 was $10.3 million versus $10.6 million for the same period in 2007. The slight decrease was primarily the net effect of the increase in inventories in 2008, offset somewhat by increased net earnings to date in 2008.

          The increase in the receivables balance from $30.6 million at December 31, 2007 to $38.0 million at June 30, 2008 was due primarily to the timing of sales and certain cash collections.

          Inventories at June 30, 2008 increased to $39.5 million from $34.1 million at December 31, 2007 due primarily to longer lead times on certain electrical components and higher overall costs of material components to support increased sales levels.

          Prepaid expenses and other current assets increased between December 31, 2007 and June 30, 2008 primarily because of the payment of certain calendar year insurance premiums that are expensed ratably over the policy period.

          Net property, plant and equipment at June 30, 2008 increased $4.6 million since December 31, 2007. This is the result of $7.5 million of capital expenditures, which included $5.6 million associated with the construction of the Company’s new plant in Nogales, Mexico, which is expected to be operational in the fourth quarter of 2008, offset by depreciation expense and disposals.

          Intangible assets increased due to the purchase of the Galaxy® proprietary fixed network AMI technology for $25.7 million early in the second quarter of 2008, offset by amortization expense.

          Short-term debt increased $21.8 million at June 30, 2008 compared to the balance at December 31, 2007, primarily as a result of the purchase of the Galaxy® technology discussed above. Long-term debt decreased as a result of regularly scheduled payments. All of the Company’s debt is unsecured and does not carry any financial covenants. In July 2008, the Company obtained a $15.0 million unsecured two-year loan that bears interest at 5.04% annually to refinance a portion of the existing short-term debt that funded this acquisition.

          Payables increased to $14.8 million at June 30, 2008 from $11.4 million at December 31, 2007 primarily as a result of the increase in inventory and the timing of payments. Accrued compensation and employee benefits increased since December 31, 2007 from $6.0 million to $7.0 million due to costs accrued for 2008 expenses to date, offset somewhat by the first quarter 2008 payment of amounts accrued at December 31, 2007.

13

          Income and other taxes increased to $10.9 million at June 30, 2008 from $8.4 million at December 31, 2007 due to increased earnings and the timing of income tax payments.

          Common stock and capital in excess of par value both increased since December 31, 2007 due to new stock issued in connection with the exercise of stock options. Employee benefit stock decreased as a result of a payment made on the Employee Savings and Stock Ownership Plan loan during the first quarter of 2008.

          Accumulated other comprehensive loss was $8.4 million at June 30, 2008 compared to a $9.2 million loss at December 31, 2007 due primarily to the amortization in the Statement of Operations of certain pension and postretirement amounts included in accumulated other comprehensive loss as required under SFAS 158 as well as the effects of foreign exchange translations.

          Badger Meter’s financial condition remains strong. The Company believes that its operating cash flows, available borrowing capacity, and its ability to raise capital provide adequate resources to fund ongoing operating requirements, future capital expenditures and development of new products. There was $22.7 million of unused credit lines at June 30, 2008.

Other Matters

          There are currently no material legal proceedings pending with respect to the Company. The more significant legal proceedings are discussed below.

          The Company is subject to contingencies related to environmental laws and regulations. Currently, the Company is in the process of resolving matters relating to two landfill sites where it has been named as one of many potentially responsible parties. These sites are impacted by the Federal Comprehensive Environmental Response, Compensation and Liability Act and other environmental laws and regulations. At this time, the Company does not believe the ultimate resolution of these issues will have a material adverse effect on the Company’s financial position or results of operations, either from a cash flow perspective or on the financial statements as a whole. This belief is based on the Company’s assessment of its limited past involvement with these sites as well as the substantial involvement of other named third parties in these matters. However, due to the inherent uncertainties of such proceedings, the Company cannot predict the ultimate outcome of these matters. A future change in circumstances with respect to these specific matters or with respect to sites formerly or currently owned or operated by the Company, or with respect to off-site disposal locations used by the Company, could result in future costs to the Company and such amounts could be material.

          Like other companies in recent years, the Company has been named as a defendant in numerous multi-claimant/multi-defendant lawsuits alleging personal injury as a result of exposure to asbestos, manufactured by third parties, and integrated into or sold with a very limited number of the Company’s products. The Company is vigorously defending itself against these claims. Although it is not possible to predict the ultimate outcome of these matters, the Company does not believe the ultimate resolution of these issues will have a material adverse effect on the Company’s financial position or results of operations, either from a cash flow perspective or on the financial statements as a whole. This belief is based in part on the fact that no claimant has demonstrated exposure to products manufactured or sold by the Company and that a number of cases have been voluntarily dismissed.

          No other risks or uncertainties were identified that could have a material impact on operations and no long-lived assets have become permanently impaired in value.

Off-Balance Sheet Arrangements and Contractual Obligations

          The Company’s off-balance sheet arrangements and contractual obligations are discussed in Part II, Item 7 “Management’s Discussion and Analysis of Financial Condition and Results of Operations” under the headings “Off-Balance Sheet Arrangements” and “Contractual Obligations” in the Company’s Annual Report on Form 10-K for the year ended December 31, 2007, and have not materially changed since that report was filed.

Item 3 Quantitative and Qualitative Disclosures about Market Risk

          The Company’s quantitative and qualitative disclosures about market risk are included in Part II, Item 7 “Management’s Discussion and Analysis of Financial Condition and Results of Operations” under the heading “Market Risks” in the Company’s Annual Report on Form 10-K for the year ended December 31, 2007, and have not materially changed since that report was filed.

14

Item 4 Controls and Procedures

Evaluation of Disclosure Controls and Procedures

          In accordance with Rule 13a-15(b) of the Securities Exchange Act of 1934 (the “Exchange Act”), the Company’s management evaluated, with the participation of the Company’s Chairman, President and Chief Executive Officer and the Company’s Senior Vice President — Finance, Chief Financial Officer and Treasurer, the effectiveness of the design and operation of the Company’s disclosure controls and procedures (as defined in Rule 13a-15(e) under the Exchange Act) as of the end of the quarter ended June 30, 2008. Based upon their evaluation of these disclosure controls and procedures, the Company’s Chairman, President and Chief Executive Officer and the Company’s Senior Vice President - Finance, Chief Financial Officer and Treasurer concluded that the Company’s disclosure controls and procedures were effective as of the end of the quarter ended June 30, 2008 to ensure that information relating to the Company, including its consolidated subsidiaries, was made known to management by others within those entities as appropriate to allow timely decisions regarding required disclosure of the information, particularly during the period in which this Quarterly Report on Form 10-Q was being prepared.

Changes in Internal Control over Financial Reporting

          There was no change in the Company’s internal control over financial reporting that occurred during the quarter ended June 30, 2008 that has materially affected, or is reasonably likely to materially affect, the Company’s internal control over financial reporting.

Part II — Other Information

Item 4 Submission of Matters to a Vote of Security Holders

          At the Company’s Annual Meeting of Shareholders held on April 25, 2008, the following individuals were elected to the Board of Directors. Beginning at the 2009 Annual Meeting of Shareholders, all directors will be elected annually to one-year terms because shareholders approved the amendment to the Company’s Restated Articles of Incorporation to declassify the board.

	Votes		Votes
	FOR		WITHHELD		Not Voted
Directors elected to the Board of Directors:
Ronald H. Dix		8,329,675		2,893,923		3,316,423
Thomas J. Fischer		8,325,507		2,898,091		3,316,423
Richard A. Meeusen		8,993,608		2,229,990		3,316,423
Directors continuing in office:
Ulice Payne, Jr.
Andrew J. Policano
Steven J. Smith
Kenneth P. Manning
John J. Stollenwerk

          At the Company’s Annual Meeting of Shareholders held on April 25, 2008, shareholders approved the Badger Meter, Inc. 2008 Restricted Stock Plan by the vote set forth below:

FOR	AGAINST		ABSTAIN		BROKER NON-VOTES
8,069,751		1,164,231		83,551		1,906,065

15

          At the Company’s Annual Meeting of Shareholders held on April 25, 2008, shareholders approved the amendment to the Restated Articles of Incorporation to declassify the Board of Directors by the vote set forth below:

FOR	AGAINST		ABSTAIN
10,382,978		659,513		181,107

Item 6 Exhibits

Exhibit No.	Description
3.1	Articles of Amendment to Restated Articles of Incorporation [Incorporated by reference to Exhibit 3.1 to the Registrant’s Registration Statement on Form 8-A, dated June 16, 2008 (Commission File No. 1-6706)].
3.2	Restated Articles of Incorporation (restated in electronic format to include all amendments through June 16, 2008) [Incorporated by reference to Exhibit 3.2 to the Registrant’s Registration Statement on Form 8-A, dated June 16, 2008 (Commission File No. 1-6706)].
4.1	Loan Agreement dated July 1, 2008 between the Registrant and the M&I Marshall & Ilsley Bank relating to the Registrant’s business note.
4.2	Badger Meter, Inc. 2008 Restricted Stock Plan [Incorporated by reference to Exhibit 4.1 to the Registrant’s Registration Statement on Form S-8, dated April 30, 2008 (Commission File No. 1-6706)].
4.3	Form of Restricted Stock Agreement used in connection with the Badger Meter, Inc. 2008 Restricted Stock Plan [Incorporated by reference to Exhibit 4.2 to the Registrant’s Registration Statement on Form S-8, dated April 30, 2008 (Commission File No. 1-6706)].
31.1	Certification by the Chief Executive Officer pursuant to Section 302 of the Sarbanes-Oxley Act of 2002.
31.2	Certification by the Chief Financial Officer pursuant to Section 302 of the Sarbanes-Oxley Act of 2002.
32	Certification of Periodic Financial Report by the Chief Executive Officer and Chief Financial Officer pursuant to Section 906 of the Sarbanes-Oxley Act of 2002.

16

SIGNATURES

Pursuant to the requirements of the Securities Exchange Act of 1934, the registrant has duly caused this report to be signed on its behalf by the undersigned thereunto duly authorized.

		BADGER METER, INC.
Dated: July 25, 2008	By	/s/ Richard A. Meeusen
		Richard A. Meeusen
		Chairman, President and Chief Executive Officer
	By	/s/ Richard E. Johnson
		Richard E. Johnson
		Senior Vice President - Finance, Chief Financial Officer and Treasurer
	By	/s/ Beverly L.P. Smiley
		Beverly L.P. Smiley
		Vice President - Controller

17

BADGER METER, INC.

Quarterly Report on Form 10-Q for Period Ended June 30, 2008

Exhibit Index

Exhibit No.	Description
3.1	Articles of Amendment to Restated Articles of Incorporation [Incorporated by reference to Exhibit 3.1 to the Registrant’s Registration Statement on Form 8-A, dated June 16, 2008 (Commission File No. 1-6706)].
3.2	Restated Articles of Incorporation (restated in electronic format to include all amendments through June 16, 2008) [Incorporated by reference to Exhibit 3.2 to the Registrant’s Registration Statement on Form 8-A, dated June 16, 2008 (Commission File No. 1-6706)].
4.1	Loan Agreement dated July 1, 2008 between the Registrant and the M&I Marshall & Ilsley Bank relating to the Registrant’s business note.
4.2	Badger Meter, Inc. 2008 Restricted Stock Plan [Incorporated by reference to Exhibit 4.1 to the Registrant’s Registration Statement on Form S-8, dated April 30, 2008 (Commission File No. 1-6706)].
4.3	Form of Restricted Stock Agreement used in connection with the Badger Meter, Inc. 2008 Restricted Stock Plan [Incorporated by reference to Exhibit 4.2 to the Registrant’s Registration Statement on Form S-8, dated April 30, 2008 (Commission File No. 1-6706)].
31.1	Certification by the Chief Executive Officer pursuant to Section 302 of the Sarbanes-Oxley Act of 2002.
31.2	Certification by the Chief Financial Officer pursuant to Section 302 of the Sarbanes-Oxley Act of 2002.
32	Certification of Periodic Financial Report by the Chief Executive Officer and Chief Financial Officer pursuant to Section 906 of the Sarbanes-Oxley Act of 2002.

18